The Utilization of Ceramic Membrane for Treating of Water from Sekanak River Palembang to Produce Clean Water

- Sisnayati, Muhammad Said, Subriyer Nasir, Dwi Putro Priadi

Abstract


The aims of this research is to produce clean water from Sekanak River by using the ceramic membrane. Also, this study is to analyze the performance of ceramic membranes in terms of its ability to reduce the pollutants contained in water from Sekanak River. The ceramic membrane was tube-shaped, made from clay (87.5 %w), iron powder (2.5 %w) and activated carbon of oil palm empty bunch (10 %w). The operation condition of membrane separation was of 15 minutes, 30 minutes, 45 minutes, 60 minutes, 75 minutes, 90 minutes and the applied  pressure  was of 1.0 bar, 1.5 bar and 2.0 bar. The reduction pollutants (Fe, Mn, Zn, NH3-N, NO2-, PO4-3,H2S, BOD5, and TSS) concentration increased with increasing the pressure and the operating time of membrane separation. After treating by the ceramic membrane, the  average rejection of Fe, Mn, Zn, NH3-N, NO2-, PO4-3, H2S, BOD5, and TSS  are 81.22%, 95.00%,  99.00%, 85.19%, 78.85%, 73.95%, 97.78%, 87.55%, and 75.46% respectively. The pollutant concentrations in the effluent were met the Environmental Quality Standards (BML).

Keywords


water treatment, ceramic membrane, pressure, time operation, clean water

Full Text:

PDF

References


P.A. Gonzalez, A.M. Urtiaga, R. Ibanez, and I. Ortiz, “State of Art and Review on The Treatment Technologies of Water Reverse Osmosis Concentratesâ€. Elsevier Water Research, 46: pp. 267-283, 2012.

Darto (2011) “Biaya Kebutuhan Air Bersih Rp. 4 triliun. Majalah Tempo Interaktif. Jakarta, Available: http://www.kimprawil.go.id/balitbang/pusair/air.

D. Kusumawardani, “Valuasi Ekonomi Air Bersih di Kota Surabayaâ€Majalah Ekonomi XXI (3), pp. 216-229, 2011.

M.S. Effendi, M.K. Arifin, and M. Hasbi, “Penggunaan Preheater Pada Basin Tipe Solar Still denga Tipe Kaca Penutup Miring Terhadap Efisiensiâ€, Spektrum Industri, 10(2), pp.108-199, 2012.

D. Marolop, “Kebutuhan Air Bersih Impian Setiap Orangâ€. Universitas Sumatera Utara. Medan, 2007.

S. Tioritz, “Kajian Solusi Krisis Air Bersih di Indonesiaâ€. Jurnal Teknik Elektro, Informatika, Mesin dan Sipil. Media Teknik, 4(1), pp.38-43, 2010.

B. Mu’min, “Penurunan Zat Organik dan Warna Pada Pengolahan Air Gambut Menggunakan Membran Ultrafiltrasi Dengan Sistem Aliran Cross Flow Yang Didahului dengan Proses Koagulasi/Flokulasi Pada Adsorpsi Karbon Aktif. Environmental Engineering Institut Teknologi Bandung, 2006.

S. Rochayati, “Pengelolaan Lahan Gambut Berkelanjutanâ€, Balai Penelitian Tanah, Badan Penelitian dan Pengembangan Pertanian. Kementerian Pertanian, pp 1-89, 2011.

S. Rivai, M. Hilman, A. Mallolongan, and A. Mawardi, “Strategi dan Rencana Tindak Nasional Pengelolaan Lahan Gambut Berkelanjutan†Kelompok Kerja Pengelolaan Lahan Gambut Nasional. Departemen Dalam Negeri Jakarta, 2006

Iswono, “Efektivitas Poly Aluminium Chlorida Terhadap Penurunan Intensitas Warna Air Gambut di Siantan Hulu Kota Pontianakâ€, Universitas Dipenogoro, Thesis , pp 1-9, 2006

F. Dewi, and Notodarmojo, “Penurunan Warna dan Kandungan Zat Organik Air Gambut Dengan Cara Two Stage Coagulation†Journal Teknik Lingkungan ITB, 13(1), pp.17-26, 2007.

I.R. Eri, and W. Hadi, “Kajian Pengolahan Air Gambut Menjadi Air Bersih dengan Kombinasi Proses UpFlow Anaerobik Filter dan Slow Sand Filterâ€. Teknik Lingkungan FTSP-ITS Surabaya, Thesis , pp 1-8, 2008.

N. I. Said, (2005), “Pengolahan Air Gambut Sederhana. Available: http://www.kimprawil.go.id/balitbang/pusair/air.

A.Yusmaniar, E. Yelmida, H.S. Yeni, Edwar and Drastinawati, “Pengolahan Air Gambut dengan Bentonitâ€. Jurnal Sains dan Teknologi Fakultas Teknik Universitas Riau, 9(2), pp. 77-81, 2010.

M.H. Al-Quinabit, “The Adsorption of Cu Ion on Bentonete. Kinetic Study. Journal Coloidal and Interface Science. 283, pp. 316-319, 2005.

W.R. Baker, Membrane Technology and Applicationsâ€. 2nd edition. Jhon Willey & Sons. California, 2004.

A. Mataram, A.F. Ismail, E. Yuliwati, T. Matsuura, S. Rizal, A. Zamheri, “ Stand-alone Water Treatment : Performance of electrospun Nanofibreâ€, Jurnal Teknologi, 78 (12), pp.103-107, 2016.

K. Özdemir, “A Ceramic Ultrafiltration Membrane System for Producing High Quality Drinking Waterâ€, Karaelmas Fen ve Müh. Derg. 6(1), pp. 41-49, 2016

K. Szymanska, A.I.Zouboulis, D.Zamboulis, “Hybrid ozonation–microfiltration system for the treatment of surface water using ceramic membraneâ€, Journal of Membrane Science, 468, pp.163-171, 2014.

A. Ali, A. Ahmed, A. Gad, “Chemical and micro structural analyses for heavy metals removal from water media by ceramic membrane filtration, Water Science Technology, (2), pp. 439-450, 2017.

K. S.. Stylianos, K. Szymanska, I. A. Katsoyiannis,and A. Zouboulis, “Novel Water Treatment Processes Based on Hybrid Membrane-Ozonation Systems: A Novel Ceramic Membrane Contactor for Bubbleless Ozonation of Emerging Micropollutants, Journal of Chemistry, Vol.2015, 2015.

H. Zhang, Z. Zhong, W. LI, W. Xing, W. Jin, “River Water Purification via a Coagulation-Porous Ceramic Membrane Hybrid Process, Chinese Journal of Chemical Engineering, 22, pp. 113-119, 2014.

A. Hög, J. Ludwig, M. Beery, “The use of integrated flotation and ceramic membrane filtration for surface water treatment with high loads of suspended and dissolved organic matter, Journal of Water Process Engineering, 6, pp. 129-135, 2015.

D. Metcalfe, P.Jarvis, C.Rockey, S.Judd, “Pre-treatment of surface waters for ceramic microfiltrationâ€, Separation and Purification Technology, 163, pp. 173-180, 2016.

T. J. Ainscough, P. Alagappan, D. L. Oatley-Radcliffe, and R. Barron, “A hybrid super hydrophilic ceramic membrane and carbon nanotube adsorption process for clean water production and heavy metal removal and recovery in remote locationsâ€, Journal of Water Process Engineeringâ€, 19, pp. 220-230, 2017

A.A. Izadpanah and A. Javidnia, “The Ability of Nanofiltration Membrane to Remove Hardness and Ions from Diluted Seawaterâ€. Water, 4, pp. 283-294, 2012.

J.A.J. Ginting, A.S. Budi, and E. Budi, “Penggunaan Membran Keramik Berbasis Zeolit dan Clay dengan Karbon Aktif Sebagai Aditif Untuk Penurunan Kadar Fe dan Mn Pada Air Tanah Daerah Bekasiâ€, in Seminar Nasional Fisika. Jakarta, 2012.

M.Z. Alam, S.A. Muyibi, and N. Kamaldin, “Production of Activated Carbon From Oil Palm Empty Fruit Bunches For Removal of Zincâ€, in Twelfth International Water Technology Conference (IWTC12). Alexandria. Egypt, 2008.

P. Sugumaran, P.V. Susan, P. R. Chandran, and S. Seshadri, “Production and Characterization of Activated Carbon from Banana Empty Fruit Bunch and Delonix Regia Fruit Podâ€. Journal of Sustainable Energy & Environment. 3, pp. 125-132, 2012.

B.N.S. Kumar, R. Suhas, S.U. Shet, and J.M. Srishaila, “Utilization of Iron Ore Tailings as Replacement to Fine Agregates in Cement Congrete Pavementsâ€, International Journal of Research in Engineering and Technology, 3(7), pp. 369-376, 2014.




DOI: http://dx.doi.org/10.18517/ijaseit.8.5.4724

Refbacks

  • There are currently no refbacks.


Published by INSIGHT - Indonesian Society for Knowledge and Human Development